文档库 最新最全的文档下载
当前位置:文档库 › IR67-21C-TR8中文资料

IR67-21C-TR8中文资料

IR67-21C-TR8中文资料
IR67-21C-TR8中文资料

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
Technical Data Sheet Top Infrared LED
IR67-21C/TR8
Features
?Compatible with infrared and vapor phase reflow solder process. ?Low forward voltage. ?View angle 120° ?Pb free ?The product itself will remain within RoHS compliant version.
Descriptions
?IR67-21C/TR8 is an infrared emitting diode in miniature SMD package which is molded in a water clear plastic with flat top view lens. The device is spectrally matched with silicon photodiode and phototransistor.
Applications
?Floppy disk drive ?Optoelectronic switch ?Camera ?VCR ?Video ?Smoke detector
Device Selection Guide LED Part No.
IR
Chip Material
GaAlAs
Lens Color
Water clear
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 1 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Package Dimensions
Notes: 1.All dimensions are in millimeters 2.Tolerances unless dimensions ±0.1mm
Absolute Maximum Ratings (Ta=25℃)
Parameter Continuous Forward Current Reverse Voltage Operating Temperature Storage Temperature Soldering Temperature *1 Power Dissipation at(or below) 25℃Free Air Temperature Symbol IF VR Topr Tstg Tsol Pd Rating 65 5 -25 ~ +85 -40 ~ +85 260 130 Units mA V ℃ ℃ ℃ mW
Notes: *1:Soldering time≦5 seconds.
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 2 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Electro-Optical Characteristics (Ta=25℃)
Parameter Radiant Intensity Peak Wavelength Spectral Bandwidth Forward Voltage Reverse Current View Angle Symbol Ee λp Δλ Condition IF=20mA IF=100mA
Pulse Width≦100μs ,Duty≦1%
Min. 1.0 --------
Typ. 1.5 7.0 940 45 1.2 1.4 -120
Max. ----1.5 1.8 10 --
Units mW /sr nm nm
IF=20mA IF=20mA IF=20mA
VF IR 2θ1/2
IF=100mA
Pulse Width≦100μs ,Duty≦1%
V μA deg
VR=5V IF=20mA
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 3 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Typical Electro-Optical Characteristics Curves
Fig.1 Forward Current vs. Ambient Temperature 140
140 120 120 100 100 80 80 60 60 40 40 20 20 0 0 -25 -25
Fig.2 Spectral Distribution
100 80 60 40 20
IF=20mA Ta=25° C
0 0
20 40 20 40
60 80 100 60 80 100
0
Fig.3 Peak Emission Wavelength Ambient Temperature
Fig.4 Forward Current vs. Forward Voltage
980
4 10
960
3 10
940
920
2 10
900 -25
0
25
50
75
100
1 10 0 1 2 3 4
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 4 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Typical Electro-Optical Characteristics Curves
Fig.5 Relative Intensity vs. Forward Current Fig.6 Relative Radiant Intensity vs. Angular Displacement
100
Ie-Radiant Intensity(mW/sr)
-20
-10
0
10
20 30
10
1.0 0.9
40 50 60 70 80 0.6 0.4 0.2 0 0.2 0.4 0.6
1
0.8 0.7
0 1 2 3
0 10
10
10
10
10 4
IF-Forward Current (mA)
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 5 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Precautions For Use
1. Over-current-proof Customer must apply resistors for protection , otherwise slight voltage shift will cause big current change ( Burn out will happen ). 2. Storage 2.1 Do not open moisture proof bag before the products are ready to use. 2.2 Before opening the package, the LEDs should be kept at 30℃ or less and 90%RH or less. 2.3 The LEDs should be used within a year. 2.4 After opening the package, the LEDs should be kept at 30℃ or less and 70%RH or less. 2.5 The LEDs should be used within 168 hours (7 days) after opening the package. 2.6 If the moisture absorbent material (silica gel) has faded away or the LEDs have exceeded the storage time, baking treatment should be performed using the following conditions. Baking treatment : 60±5℃ for 24 hours. 3. Soldering Condition 3.1 Pb-free solder temperature profile
3.2 Reflow soldering should not be done more than two times. 3.3 When soldering, do not put stress on the LEDs during heating. 3.4 After soldering, do not warp the circuit board.
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 6 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
4.Soldering Iron Each terminal is to go to the tip of soldering iron temperature less than 280℃ for 3 seconds within once in less than the soldering iron capacity 25W. Leave two seconds and more intervals, and do soldering of each terminal. Be careful because the damage of the product is often started at the time of the hand solder. 5.Repairing Repair should not be done after the LEDs have been soldered. When repairing is unavoidable, a double-head soldering iron should be used (as below figure). It should be confirmed beforehand whether the characteristics of the LEDs will or will not be damaged by repairing.
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 7 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Reliability Test Item And Condition The reliability of products shall be satisfied with items listed below. Confidence level:90% LTPD:10% NO. Item Test Conditions Test Hours/ Sample Cycles Sizes 22pcs 22pcs IR≧U×2 Ie≦L×0.8 VF≧U×1.2 U:Upper Specification Limit L:Lower Specification Limit Failure Judgement Criteria Ac/Re
1 REFLOW Soldering TEMP.:260℃±5℃ 6Mins 10secs 15mins 50Cycles 2 Temperature Cycle H : +100℃ 5mins L : -40℃ 15mins 3 Thermal Shock H :+100℃ L :-10℃ 4 High Temperature Storage 5 Low Temperature Storage 5mins 50Cycles 10secs 5mins 1000hrs 1000hrs 1000hrs 1000hrs
0/1 0/1
22pcs
0/1
TEMP.:+100℃ TEMP.:-40℃
22pcs 22pcs 22pcs 22pcs
0/1 0/1 0/1 0/1
6 DC Operating Life IF=20mA 7 High Temperature/ 85℃ / 85% R.H High Humidity
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 8 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Package Dimensions
Taping Dimensions
Unit: mm
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 9 of 10
Prepared by:Jaine Tsai

元器件交易网https://www.wendangku.net/doc/1e1518221.html,
IR67-21C/TR8
Packing Quantity Specification
1.2000Pcs/1Volume,1Volume/1Bag 2.10Boxes/1Carton
Label Form Specification
CPN: Customer’s Production Number P/N : Production Number QTY: Packing Quantity CAT: Ranks HUE: Peak Wavelength REF: Reference LOT No: Lot Number MADE IN TAIWAN: Production Place
IR67-21C/TR8
Notes
1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent.
EVERLIGHT ELECTRONICS CO., LTD. Office: No 25, Lane 76, Sec 3, Chung Yang Rd, Tucheng, Taipei 236, Taiwan, R.O.C Tel: 886-2-2267-2000, 2267-9936 Fax: 886-2267-6244, 2267-6189, 2267-6306 http:\\https://www.wendangku.net/doc/1e1518221.html,
Everlight Electronics Co., Ltd. Device No:DTR-067-037
http:\\https://www.wendangku.net/doc/1e1518221.html, Prepared date:04-11-2007
Rev 2
Page: 10 of 10
Prepared by:Jaine Tsai

相关文档