STRW6753中文资料
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
Data Sheet
28103.31*
STR-W6753
Sanken Power Devices from Allegro MicroSystems
S w i t c h i n g R
e g u l a t o r s
ABSOLUTE MAXIMUM RATINGS
at T A = +25°C
Control Supply Voltage, V CC . . . . 35 V Drain-Source Voltage, V DSS . . . . . . 650 V Drain Switching Current, I D . . . 11.2 A*Peak Drain Switching Current,
I DM . . . . . . . . . . . . . . . . . . . . . 11.2 A Single-Pulse Avalanche Energy,
E AS . . . . . . . . . . . . . . . . . . . 145 mJ OCP/BD Voltage Range,
V OCP . . . . . . . . . . . . –1.5 V to +5 V FB Input Current, I FB . . . . . . . . 10 mA FB Voltage Range, V FP –0.5 V to +9 V Package Power Dissipation, P D
control (V CC × I CC(ON)). . . . . . 0.8 W MOSFET (V DSS × I D ). . . See Graph MOSFET Channel Temp., T J . +150°C Internal Frame Temp., T F . . . . +115°C Operating Temperature Range,
T A . . . . . . . . . . . -20°C to +115°C?Storage Temperature Range,
T S . . . . . . . . . . . . -40°C to +125°C
* Drain switching current is limited by tem-perature (page 2) and safe operating area (page 5).
?For the availability of parts meeting -40°C
requirements, contact Allegro’s Sales Represen-tative.
The STR-W6753 is a quasi-resonant regulator specifically designed to satisfy the requirements for increased integration and reliability in switch-mode power supplies. It incorporates a primary control and drive circuit with an avalanche-rated power MOSFET. The regulator exhibits only low-level high-frequency EMI noise because of soft switching of the MOSFET close to ground (bottom point). A bottom-skip function minimizes an increase of operational frequency during light loads to improve system efficiency over the entire load range.
Covering the power range from below 120 watts for a 230 VAC input, or 58 watts for a universal input (85 to 264 VAC), this device can be used in a range of applications, from DVD and VCR players to ac adapters for cellular phones and digital cameras. An auto-standby function, which is internally triggered by sensing on time, reduces
power consumption at light load. An externally triggered standby mode reduces the input power further. Multiple protections, including the avalanche-energy-guaranteed MOSFET, provide high reliability of system design. Devices with an increased output power rating are the STR-W6754 and STR-W6756.
Cycle-by-cycle current limiting, undervoltage lockout with hyster-esis, and overvoltage protection protect the power supply during the normal overload and fault conditions. Overvoltage protection is latched after a short delay. The latch may be reset by cycling the input supply.Low start-up current and a low-power standby mode selected from the secondary circuit completes a comprehensive suite of features. The STR-W6753 is provided in a fully molded TO-220-style flange-mounted, high power, isolated plastic package.
FEATURES AND BENEFITS
■Rugged 650 V Avalanche-Rated MOSFET Simplified Surge Absorption No V DSS Derating Required ■ 1.7 ? Maximum r DS(on)
■Two Operational Modes by Automatic Switching:Quasi-Resonant Mode for Normal Operation
Burst Mode for Standby Operation or Light Loads ■Automatic or Manually Triggered Burst Standby Input Power <0.1 W at No Load ■Low Operating Current (6 mA typ)
— continued Always order by complete part number, e.g., STR-W6753 .
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
S w i t c h i n g R
e g u l a t o r s FUNCTIONAL BLOCK DIAGRAM
FEATURES AND BENEFITS (cont’d)
■Auto-Bias Function
Stable Burst Operation Without Generating Interference ■Internal Off-Timer Circuit
■Built-In Constant-Voltage Drive ■Multiple Protections:
Pulse-by-Pulse Overcurrent Protection Overload Protection with Auto Recovery Latching Overvoltage Protection
Undervoltage Lockout with Hysteresis ■RoHS Compliant
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
https://www.wendangku.net/doc/1d3299673.html,
3
S w i t c h i n g R
e g u l a t o r s ELECTRICAL CHARACTERISTICS at T A = +25°C, V CC = 20 V, voltage measurements are referenced to S/GND terminal (unless otherwise specified).
Limits
Characteristic Symbol
Test Conditions
Min.
Typ.
Max.
Units
Start-Up Operation Operation Start Voltage
V CC(ON)Turn-on, V CC = 0 19.9 V
16.318.219.9V Soft-Start Operation Stop Voltage V SS/OLP 1.1 1.2 1.4V Soft-Start Oper. Charging Current I SS/OLP -390-550-710μA Operation Stop Voltage V CC(OFF)Turn-off, V CC = 19.9 8.8 V 8.89.710.6V Circuit Current in Non-Operation I CC(OFF)
V CC = 15 V
–
–
100
μA
Normal Operation
Drain-Source Breakdown Voltage V (BR)DSS I D = 300 μA 650––V Drain Leakage Current I DSS
V DS = 650 V
––300μA On-State Resistance r DS(on)
I D = 1.4 A, T J = +25°C
–– 1.7?Switching Time t f ––400ns Circuit Current I CC(ON)–– 6.0mA Oscillation Frequency
f osc 192225kHz Bottom-Skip Oper. Threshold Volt.
V OCPBD(BS1)-605-665-720mV V OCPBD(BS2)
-385-435-485mV Quasi-Resonant Oper. Threshold V OCPBD(TH1)280400520mV V OCPBD(TH2)
670800930mV Feedback-Pin Threshold Voltage V FB(OFF) 1.32 1.45 1.58V Feedback-Pin Current I FB(ON)
600
1000
1400
μA
Standby Operation
Standby Operation Start Voltage V CC(S)V CC = 0 12.2 V 10.311.112.1V Standby Oper. Start Volt. Interval V CC 1.10
1.35 1.65V Standby Non-Operation Current I CC(S)V CC = 10.2 V –2056μA Feedback-Pin Current
I FB(ON)V CC = 10.2 V – 4.014μA Feedback-Pin Threshold Voltage V FB(S)V CC = 12.2 V
0.55 1.10 1.50V Minimum ON Time
t on(min)
0.5
0.8
1.2
μs
continued next page ...
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
S w i t c h i n g R
e g u l a t o r s Protection Operation OVP Operation Voltage V CC(OVP)Turn-off, V CC = 0 29.9 V 25.527.729.9V Maximum ON Time t on(max)27.532.539.0μs OLP Operation Voltage V SSOLP 4.0 4.9 5.8V OLP Operation Current
I SSOLP -6.0
-11
-16
μA Overcurrent Detect. Threshold Volt.V OCPBD(LIM)-0.895-0.940-0.995V OCP/BD-Pin Current I OCPBD -40
-100-250μA Latch Holding Current I CC(H)V CC = 29.9 V CC(OFF) – 0.3 V –45140mA Latch Release Voltage V CC(L)
V CC = 29.9 6 V
6.0
7.2
8.5
V
Other
Thermal Resistance
R θJF
Output junction-to-frame –– 2.0°C/W
NOTES: 1. Typical Data is for design information only.
2. Negative current is defined as coming out of (sourcing) the specified device termninal.
ELECTRICAL CHARACTERISTICS at T A = +25°C, V CC = 20 V, voltage measurements are referenced to S/GND terminal (unless otherwise specified).
Limits
Characteristic Symbol Test Conditions Min.Typ.Max.Units
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
https://www.wendangku.net/doc/1d3299673.html,
5
S w i t c h i n g R
e g u l a t o r
s Avalanche energy is measured at V DD = 99 V,
L = 20 mH, I L = 3.6 A.
MOSFET TYPICAL CHARACTERISTICS
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
S w i t c h i n g R
e g u l a t o r s MOSFET TYPICAL CHARACTERISTICS (cont’d)
WARNING — These devices are designed to be operated at lethal voltages and energy levels. Circuit designs
that embody these components must conform with applicable safety requirements. Precautions must be taken to prevent accidental contact with power-line potentials. Do not connect grounded test equipment.
The use of an isolation transformer is recommended during circuit development and breadboarding.
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
https://www.wendangku.net/doc/1d3299673.html,
7
S w i t c h i n g R
e g u l a t o r s Complete product description and applications information is provided in Application Note 28103.30, Series STR-W6750 Off-Line Quasi-Resonant Flyback Switching Regulators .
Typical Application
APPLICATIONS INFORMATION
The products described herein are manufactured in Japan by Sanken Electric Co., Ltd. for sale by Allegro MicroSystems, Inc.
Sanken and Allegro reserve the right to make, from time to time, such departures from the detail specifications as may be required to permit improvements in the performance, reliability, or manufacturability of its products. Therefore, the user is cautioned to verify that the information in this publication is current before placing any order.
When using the products described herein, the applicability and
suitability of such products for the intended purpose shall be reviewed at the users responsibility.
Although Sanken undertakes to enhance the quality and reliability of its products, the occurrence of failure and defect of semiconductor products at a certain rate is inevitable.
Users of Sanken products are requested to take, at their own risk,preventative measures including safety design of the equipment or systems against any possible injury, death, fires or damages to society due to device failure or malfunction.
Sanken products listed in this publication are designed and intended for use as components in general-purpose electronic equipment or apparatus (home appliances, office equipment, telecommunication equipment, measuring equipment, etc.). Their use in any application requiring radiation hardness assurance (e.g., aerospace equipment) is not supported.
When considering the use of Sanken products in applications where higher reliability is required (transportation equipment and its control systems or equipment, fire- or burglar-alarm systems, various safety devices, etc.), contact a company sales representative to discuss and obtain written confirmation of your specifications.
The use of Sanken products without the written consent of Sanken in applications where extremely high reliability is required (aerospace equipment, nuclear power-control stations, life-support systems, etc.) is strictly prohibited.
The information included herein is believed to be accurate and
reliable. Application and operation examples described in this publica-tion are given for reference only and Sanken and Allegro assume no responsibility for any infringement of industrial property rights,
intellectual property rights, or any other rights of Sanken or Allegro or
any third party that may result from its use.
EI16EI
STR-W6753
Universal-Input/58 W Off-Line Quasi-Resonant Flyback Switching Regulator
S w i t c h i n g R
e g u l a t o r s PACKAGE DIMENSIONS
in Millimeters
Product weight: approx. 2.3 g.
Recommended mounting hardware torque: 0.588 ~ 0.785 Nm, 6 ~ 8 kgf × cm.
Recommended silicon grease: Dow Corning SC102, Toshiba YG6260, Shin-Etsu G746, or equivalent.