铁红醇酸防锈漆中英文MSDS
铁红醇酸防锈漆MSDS
l
性状危险性
油漆闪点：约34℃
主要有害成份:
200#汽油：
爆炸上限%（V/V）：6.0 爆炸下限%（V/V）：1.3
饱和蒸汽压（KPa）：
1.33(32℃) 产品内所含溶剂为易燃性和挥发性有机物质，若与空气接触，
积聚到一定浓度极限时，一旦接触明火、火花、静电或高热，很
容易引起火灾。燃烧时放出一氧化碳，二氧化碳有毒气体。
安全运输、涂装及储存
搬运时要轻装轻卸，防止包装和容器破损。
运输时运输车辆应配备相应品种和数量的消防器材及泄漏应
急处理设备。运输时严禁与食用化学品等混装混运。运输途中应
防曝晒、雨淋、防高温。中途停留时应远离火种热源。避免与氧
化剂接触。运输车辆要有接地装置，防止静电的积聚。
储存于阴凉，通风的库房，远离火种，热源。库温不宜超过
40℃。保持容器密封。采用防爆型照明、通风设施。
施工及待干过程要有良好的通风环境，保证的持续流通的新鲜
空气，施工者应注意配戴防护用品，避免人体接触油漆的吸入溶
剂，并注意防火、安全。
急救措施防护措施灭火材料
●皮肤接触：脱去污染的衣着，
用肥皂水和清水彻
底冲洗皮肤。
●眼睛接触 : 立即提起眼睑，用
大量流动清水或生
理盐水冲洗至少15
分钟，就医。
●食入：饮足量温水，催吐，就
医。
●吸入：迅速脱离现场至空气新
鲜处，保持呼吸道畅
通，呼吸困难时给输
氧，如呼吸及心跳停
止，立即进行人工呼
吸和心脏按摩术，就
医。●呼吸系统防护：空气中浓度超
标时，佩戴自吸过
滤式防毒面具（半
面罩）。紧急事态
抢救或撤离时，应
该佩戴空气呼吸
器。
●眼睛防护：戴化学安全防护
眼镜。
●身体防护：穿一般作业防护服
●手防护：戴橡胶耐油手套
●其它防护：工作现场禁止吸
烟、进食和饮水，工作完毕，淋
浴更衣。实行就业前和定期的体
检。
●用抗溶性泡沫、干粉、二氧
化碳、1211、砂土。喷水冷
却容器，可能的话将容器从
火场移至空旷处。
编制：审核：编制日期：实施日期：
MSDS of Iron Red Alkyd Anti-rusting Paint
Characteristics Hazard, dangerousness Flash point of the paint:
about 34℃
Main harmful ingredients: Xylene:
Explosion upward limit（V/V）:
7.0
Explosion downward limit%
（V/V）: 1.1 Saturated vapour
pressure:(KPa):1.33
(32℃)
200# gasoline:;
Explosion upward limit（V/V）:
6.0
Explosion downward limit%
（V/V）: 1.3 Saturated vapour
pressure:(KPa):1.33
(32℃) Solvents contained in this product are inflammable and
volatile material,Air and vapor of this product may form an
explosive mixture which will be burnt if met with fire,
static electricity or high heat, poisonous gases like carbon
monoxide,carbon dioxide will be released during the
combustion.
Safety transportation,coating and storage
C arefully and gently load, unload and transport the
product, avoid damage of package or container.
Provide appropriate fire extinguishing equipment and
facilities of emergency leak treatments on the
transportation.Strictly avoid mixing, loading and
transport with chemicals for food use .Exposure to sun light,
rain, and high temperature should be avoided on the way of
transportation. Keep distance from flame, heat and strong
oxidizing agents. Vehicles for transportation should have
grounding device to avoid accumulating of static electricity.
The product should be stored in a cool and well ventilated
warehouse and should be kept distance with fire and heat
sources, the suitable storage temperature being less than
40℃. Keep the paint containers tightly closed. Use lighting facility
and ventilation facility of explosion proof type.
Working place should be well ventilated, using tools and
installations of flameproof type. Operators is suggested to
wear gas masks ,safety protective glasses and rubber
oil-resistant gloves Avoid human bodies to contact with
the product and inhalation of solvent vapor.Pay attention
to safety and fire prevention.
First aid measures Safeguard procedures Fire extinguishing material
Contact with skin ：
Take off the contaminated
clothes, rinse skin
thoroughly with soap
water and clear water. Contact with eyes:
Take up the eye lips，rinse with
running clear water or
physiological saline
for at least 15 minutes,
seek medical advice
if needed.
Take in：
Drink enough amount of warm
water, press vomiting,
and the very sick
person should seek
medical advice. Breathe in ：
Leave the scene rapidly to the
site with fresh air,
keep respiratory tract
unimpeded, give
oxygen therapy if
breath is in
difficulty(despnoea),
give recue breathing if
respiratory arrest, give
heart massage if
cardiac arrest, then
seek medical advice as
soon as possible. Protection of respiratory
system：
Wear gas mask during work
when the
concentration in
the air exceed the
acceptable limit
Protection of eyes ：wear
safety protective
glasses;
Protection of body ：wear
relevant
protective working
clothing ;
Protection of hands ：wear
chemical-resistant
rubber gloves.
Other protections ： Do not
smoke, eat , and
drink in the
working place.
Take bath and
change clothes
after work. Carry
out health
examination
pre-job and at
regular intervals.
Use solvent resistant
foam, dry powder, carbon
dioxide, 1211,sand and
soil Spray water to cool
down the containers, and
remove containers from
fire site to open space if
it is possible.
Authorized personnel: Auditor: Date of establishment: Date of implement: